Ilaria Rubino is shown in this undated handout image at University of Alberta. Alberta researcher Rubino has developed technology allowing mostly salt to kill pathogens in COVID-19 droplets as they land on a mask. THE CANADIAN PRESS/HO-University of Alberta

Ilaria Rubino is shown in this undated handout image at University of Alberta. Alberta researcher Rubino has developed technology allowing mostly salt to kill pathogens in COVID-19 droplets as they land on a mask. THE CANADIAN PRESS/HO-University of Alberta

Alberta researcher gets award for COVID-19 mask innovation

The salt-coated mask is expected to be available commercially next year after regulatory approval.

Salt that crystallizes with sharp edges is the killer ingredient in the development of a reusable mask because any COVID-19 droplets that land on it would be quickly destroyed, says a researcher who is being recognized for her innovation.

Ilaria Rubino, a recent PhD graduate from the department of chemical and materials engineering at the University of Alberta, said a mostly salt and water solution that coats the first or middle layer of the mask would dissolve droplets before they can penetrate the face covering.

As the liquid from the droplets evaporates, the salt crystals grow back as spiky weapons, damaging the bacteria or virus within five minutes, Rubino said.

“We know that after the pathogens are collected in the mask, they can survive. Our goal was to develop a technology that is able to inactivate the pathogens upon contact so that we can make the mask as effective as possible.”

Rubino, who collaborated with a researcher at Georgia State University in Atlanta to advance the project she started five years ago, was recognized Tuesday with an innovation award from Mitacs. The Canadian not-for-profit organization receives funding from the federal government, most provinces and Yukon to honour researchers from academic institutions.

The reusable, non-washable mask is made of a type of polypropylene, a plastic used in surgical masks, and could be safely worn and handled multiple times without being decontaminated, Rubino said.

The idea is to replace surgical masks often worn by health-care workers who must dispose of them in a few hours, she said, adding the technology could potentially be used for N-95 respirators.

The salt-coated mask is expected to be available commercially next year after regulatory approval. It could also be used to stop the spread of other infectious illnesses, such as influenza, Rubino said.

Dr. Catherine Clase, an epidemiologist and associate professor of medicine at McMaster University in Hamilton, said the “exciting” technology would have multiple benefits.

Clase, who is a member of the Centre of Excellence in Protective Equipment and Materials in the engineering department at McMaster, said there wasn’t much research in personal protective equipment when Rubino began her work.

“It’s going to decrease the footprint for making and distributing and then disposing of every mask,” she said, adding that the mask could also address any supply issues.

The Public Health Agency of Canada recently recommended homemade masks consist of at least three layers, with a middle, removable layer constructed from a non-woven, washable polypropylene fabric to improve filtration.

Conor Ruzycki, an aerosol scientist in the University of Alberta’s mechanical engineering department, said Rubino’s innovation adds to more recent research on masks as COVID-19 cases rise and shortages of face coverings in the health-care system could again become a problem.

Ruzycki, who works in a lab to evaluate infiltration efficiencies of different materials for masks and respirators, is also a member of a physician-led Alberta group Masks4Canada, which is calling for stricter pandemic measures, including a provincewide policy on mandatory masks.

Camille Bains, The Canadian Press


Like us on Facebook and follow us on Twitter.

Want to support local journalism during the pandemic? Make a donation here.

Coronavirus

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

A pinniped was attacked by an unseen predator off the shores of Dallas Road Monday night. (Courtesy of Steffani Cameron)
VIDEO: Seal hunting, not being hunted in video shot off Dallas Road

Victoria woman captures footage of pinniped activity off Dallas Road

West Shore RCMP is looking for a suspect and their minivan, which crashed into a parked vehicle and home along the 200-block of Island Highway in View Royal on Jan. 18. (Black Press Media file photo)
Driver crashes into parked car and home in View Royal, speeds away: RCMP

Incident took place near 200-block of Island Highway Monday night

In January, six flights with cases of COVID-19 onboard have landed at the Victoria International Airport so far. (Black Press Media file photo)
Two new COVID-19 exposures reported on flights to Victoria

A Jan. 10 flight from Toronto and Jan. 11 flight from Calgary were affected

Firefighters respond to a fire on Heatherly Road in Colwood Jan. 19. (Photo courtesy of View Royal Fire Rescue)
Two people escape injury in Colwood house fire

Heatherly Road fire started on a covered porch

B.C. Representative for Children and Youth Jennifer Charlesworth (Black Press files)
B.C. watchdog says mentally ill children and youth retraumatized in hospital

The number of children held under the Mental Health Act has increased an alarming 162 per cent in past decade

A new video from NCCIH and BC Northern Health titled ‘Healing in Pandemic Times: Indigenous Peoples, Stigma and COVID-19’ was animated by Joanne Gervais. (Photo Provided By: NCCIH Archives)
VIDEO: Stigma against Indigenous people is a ‘social sickness’

A new short animated video is aiming to educate the public on the stigmatization

(Black Press Media file photo)
From arts to environment, nominate your West Shore hero

Nominations for the Goldstream Gazette’s Local Hero awards are open

Nanaimo RCMP are investigating after a threat was made at Woodgrove Centre on Tuesday, Jan. 19. (News Bulletin file photo)
Threat directed at Nanaimo mall, RCMP investigating

Police have searched areas of Woodgrove Centre accessible to shoppers and have deemed it safe

Prime Minister Justin Trudeau provides an update on the COVID-19 pandemic from Rideau Cottage in Ottawa on Tuesday, Jan. 11, 2021. THE CANADIAN PRESS/Sean Kilpatrick
Prime Minister Justin Trudeau provides an update on the COVID-19 pandemic from Rideau Cottage in Ottawa on Tuesday, Jan. 11, 2021. THE CANADIAN PRESS/Sean Kilpatrick
Trudeau vows to keep up the fight to sway U.S. on merits of Keystone XL pipeline

Canada’s pitch to the Biden team has framed Keystone XL as a more environmentally friendly project than original

The British Columbia Hotel Association (BCHA) sent out a sharply worded release late last week, in which it noted that the Tourism Industry Association of BC recently obtained a ‘legal opinion’ on the matter (Alex Passini photo)
Hotel associations push back against any potential ban on inter-provincial, non-essential travel restrictions

B.C. Premier John Horgan is seeking legal advice on banning non-essential travel

JaHyung Lee, “Canada’s oldest senior” at 110 years old, received his first dose of the COVID-19 vaccine on Thursday, Jan. 14, 2021. He lives at Amenida Seniors Community in Newton. (Submitted photo: Amenida Seniors Community)
COVID rapid tests in long-term care key during vaccine rollout: B.C. care providers

‘Getting kits into the hands of care providers should be a top priority,’ says former Health Minister

Island Health chief medical officer Dr. Richard Stanwick receives a first dose of Pfizer vaccine, Dec. 22, 2020. (B.C. government)
B.C. turns to second doses of COVID-19 vaccine as supplies slow

Pfizer shipments down until February, to be made up in March

B.C.’s Ministry of Advanced Education and Skills Training announced funding to train community mental health workers at four B.C. post-secondary institutions. (Stock photo)
B.C. funding training of mental health workers at four post-secondary institutions

Provincial government says pandemic has intensified need for mental health supports

Most Read